Reply to Thread

Post a reply to the thread: 6-cyl double vanos problem assessment

Your Message

Click here to log in

Please correctly re-type the phrase f o o t d o c t o r in the form box. Re-type it without the extra spaces and put the one space where it should be. We apologize for having to do this but this silliness helps slow the spammers.

 

Additional Options

HTML

Topic Review (Newest First)

  • 11-06-2013, 04:06 PM
    billzhao
    I need your help on how to safe to remove and install splined shaft without damage any part or mess up with timing chain. I do not have any Camshaft Timing Set tools.
    I appreciate your help!
    Bill
  • 10-20-2011, 10:40 AM
    MissyJ
    Ithink ours is way to far out of warranty for that. still investigating the 'Vanos" thing, not sure what all the Symptoms are. But it is always nice when the dealers treat you like they should!, and I will remember to bring the donuts next time I have to go in for service..hehehe

    thanks, Missy
  • 10-20-2011, 10:37 AM
    MissyJ
    OK, swapped out #5 coil (showing misfire) with #2 coil test drove and "happened" to stop by the local import service shop and the nice guys did a total wipe on the codes for me. on the way home drove it hard, and code p1345 popped up (P1345Misfire Cylinder 2 With Fuel Cut-off) so it moved with the coil. hopefully changing the coils fixes our problems ***fingers crossed***
  • 10-20-2011, 09:25 AM
    Gans
    my dealer replaced entire vanos unit under a sort of good will warranty , car was two years out of warranty. Treated like CPO charged me $50 and provided a loaner. Of course the problem will comeback again as the replacement vanos unit has same part number and has not changed.Bringing donuts during any service appointment always pays.
  • 10-20-2011, 08:29 AM
    MissyJ
    OK guys.... A little help here... Please. We have a 2001 330i, we love it to death! but we have been doing a LOT of DIY on it lately(past 3 years)!! about a month ago SES came on finally got around yesterday to putting code reader on it.. shows code p1351 changed out ALL spark plugs, going out in a few minutes to swap out coil #5 with another and reset code then drive it again. code ALWAYS pops when you get on it hard, say for instance when you are going to pass another car. it has also been acting a different under cold conditions also (she doesn't like Georgia to well,neither do I, just moved here from California in July) Any ideas would be greatly appreciated!!

    Thanks,
    Missyj
  • 01-19-2011, 01:22 AM
    jsbruin

    Re: Seals solution

    I am new to this forum and have to say that I'm thrilled that I might have found a resolution to my cold start hesitation and stalling problem (2000 e39). I've been looking into this on and off for 8 years. I will test tomorrow.

    Does anyone know of a Los Angeles, CA mechanic that has done this before? And other than the cost of the seals, do you know how much the repair costs?

    Thanks for you help.

    Cheers
  • 01-06-2011, 03:15 PM
    M. Florence Oliverio

    Re: Symptoms fixed with DME update

  • 10-15-2010, 04:36 PM
    Filehorse

    I suggest you take a dirt nap...!!




    Filehorse
    Knoxville, TN
    BMWCCA #407627

    2002 525i Steptronic Sport/Premium | Build Date: 05/02
    79,000 Ultimate Driving miles
    Xenons
    Style 81s | Bridgestone Potenza RE960 AS
    Titanium Gray | Gray Leather
    35% LLumar ATR LLumaStar tint
    Valentine 1 | Hardwired
    Steering wheel position memory w/Alzheimers
    "Lifetime" ATF replaced at 40,000
    StopTech SportStop slotted rotors w/Axxis Deluxe Advanced pads
    StopTech SS Braided Brake Lines

    2001 E46 325i (Jet Black) Forced Retirement 6/28/09

    2001 E46 325i (Orient Blue) Forced Retirement 10/09

    1989 E30 325i (Alpine White) Retired
  • 10-15-2010, 04:25 PM
    anymnallemiat

    Stress some suggestions

    Does anyone have knowledge of a honourable concern to upon newborn gifts? I desire to swallow a little rag doll with my nephews rank on it for his christening. I acquire create some exceedingly proper sites, by reason of illustration christmas stockings , but If anyone can recomend safer I would apreciate it. Thanks!
  • 07-06-2010, 09:58 PM
    anymnallemiat

    Desideratum some suggestions

    Does anyone identify a honourable put out to perceive babe gifts? I desire to allow a wee rag doll with my nephews name on it payment his christening. I have found some as a matter of fact good sites, by reason of illustration decorated christmas trees , but If anyone can recomend better I would apreciate it. Thanks!
  • 07-06-2010, 11:37 AM
    anymnallemiat

    Have need of some suggestions

    Does anyone have knowledge of a sensible put out to find coddle gifts? I desire to swallow a pygmy attire doll with my nephews name on it against his christening. I have ground some as a matter of fact well-mannered sites, representing standard naming day presents , but If anyone can recomend safer I would apreciate it. Thanks!
  • 05-29-2010, 01:57 PM
    Mike Levy

    You revived the hell thread for this???!!!!

    I can't believe you brought the thread from hell back up for SPAM! I should run your IP, find you and beat the hell out of you for being a SPAMMING [Oops!].
  • 05-29-2010, 01:39 PM
    anymnallemiat

    Desideratum some suggestions

    Does anyone have knowledge of a honourable scene to find coddle gifts? I homelessness to believe a pygmy rag doll with my nephews label on it against his christening. I have set up some as a matter of fact good sites, by reason of standard children's gifts , but If anyone can recomend bigger I would apreciate it. Thanks!
  • 02-09-2010, 06:33 AM
    bmw76

    Re: 6-cyl double vanos problem assessment

    I have a 325i M54 engine.
    I had a slight rattle between 3k RPM. Was planning to change the o rings as outlined in Beisan Systems 6-cylinder Double Vanos Procedure (E46, E39) but know a very long knocking from the vanos.
    The engine management light is up , but i need to read the error code.

    Can the bearings in the vanos and / or splined shafts (cups) attached to pistons fail ?


    Has anybody else had such a problem ?

    Any help would be appreciated.
  • 09-21-2009, 10:45 AM
    HarryP

    Make it so.

  • 09-19-2009, 04:08 AM
    Tinkerbell

    Re: Is this problem only for 99-00 I6, or 99-03?

    Aye mateys, we've again been neglecting this thread and I know you all have the need to enjoy it yet once more ;-)
  • 06-20-2009, 02:34 AM
    Gadjo.Dilo

    Prepare photon torpedos. Kill this thread!

  • 06-19-2009, 08:30 PM
    jimlev

    OK Captain Gadjo


    "Drive It Like You Stole It, A Sickness for Quickness"
    The Bottle Rocket "King of Spray" 2 Stage Nitrous Oxide
    Dare to be different and stand out among the crowd of me-to-cars!
    No guts, no glory! Tire smoke, not traction control!
    Zionsville all aluminum radiator to replace the 3 leak prone Nissens Radiators!

    NOS Progressive 2 Stage Controller w/3 injectors
    Snow's Performance Methanol/Water Injection
    Dinan downloads, VAC Under Drive Pulleys
    Dinan Carbon Fiber CAI
    Dinan Front Strut Bar
    Electric Cooling Fan w/PWM controller
    NGK Iridium Plugs
    DDE Enhanced Angel Eyes, Smoked Lenses
    Koni FSD's/H&R Springs, BAV Brass Caliper Bushings
    Eisenmann Race Exhaust (from H8-Rain's car)
    ///M5 3.15 LSD
    ///M5 Sway Bars, Front & Rear
    Energy Suspension Polyurethane Bushings
    ///M5 Gauge Cluster Rings ///M5 Lip Spoiler
    ///M5 Mirrors and Switches
    Leather Z weighted shift knob (thanks H8-Rain)
    Rogue ďOctaneĒ Short Shift kit w/WSR
    Rogue Tranny Mounts
    StopTech Brake Lines Front & Rear
    Axxis Deluxe Plus pads Front & Rear
    Staggered M Parallel 66, Xenons
    Modified CDV, UGDO
    Redline in Diff and Tranny
    Passport 8500 X50, Escort ZR3 Laser Jammer
    G-Tech/Competition Pro Data Logger
    Auto Enginuity OBD-II Scan Tool
    25% Tint, X-Pel, LoJack
    PIAA Driving Lights
    BMW CCA Member Boston Chapter
  • 06-19-2009, 05:15 PM
    Gadjo.Dilo

    "It's life Jim. But not as we know it" (nt)

  • 06-19-2009, 04:01 PM
    kbud

    Stayin alive, stayin alive, ah ah ah ah ah :)

    the thread that keeps on going :)





    K-Bud ([email protected])
    Baltimore, MD

    99' BMW E39 540iA Sp. (Prod. 11/98)
    Titanium Silver/Black
    04' Lexus GX470 (Prod. 10/03)
    Ash Blue Mica/Dark Gray
    04' Lincoln Navigator aka "King Kong" (Prod. 12/03)
    Black/Tan
    05' Primo Scooter 49cc's Red/Silver

    Roadfly Member #71563 est. 06/03
    BMWCCA Member #312125 est. 04/03

    ****Disclaimer: Down the page alot farther after all the absurd amount of pictures & vids I've posted of my current rides you'll find the "mods" for my BMW****




    Lil K-Bud's 1st Ride...Lil Blue4U, get your pink slip ready, I'm gonna toast ya!



    Mods to Date:
    DINAN Stage II, DINAN Tranny SW, DINAN Fr. Strut Bar, RevHigh CAI w/ PC'd Gunmetal Metallic Pipe, Breyton Fr. Lip Spoiler, Fr. Lip RaceMesh Grill 5/8" PC'd Black, Hella Celis Clear Rears, Clear Fronts, Clear Sides, 19" RDSport S4's w/ Gunmetal Metallic PC'd Centers 19x9 et18 Fr. & 19x10 et20 Rr., Toyo T1R's 245/35 Fr. & 275/30 Rr., Eisenmann Sport Quad Exhaust w/OE Resonator, McGard Wheel Locks, Rolled Rr. Fenders, ///M5 Rr. Wheel Liners, H&R Sp. Springs, Koni Adj. Sp. Struts, Energy Suspension Polyurethane Bushings, ///M5 Fr. Brakes w/ SS Lines, Brembo Rr. Brakes w/SS Lines, Axxis Deluxe Brake Pads, ///M5 Fr. & Rr. Swaybars, ///M5 Kidney Grills, ///M5 Brushed Gauge Rings, 2.25" Magnaflow High Flow Cats, ///M-Tech Rr. Bumper, ///M5 Trunk Lip Spoiler, ///M5 Style Side Mirrors ,DDE Xenon Match Angel Eyes, Xenon Match H7 Fog Bulbs, AC Schnitzer Alum. Pedals, Denso Iridium Plugs, In-Dash Business CD Player, Blk. Metallic Int. Trim, Brushed Alum. & Blk. Lthr. Shift Selector Knob, 35% Window Tint, Homelink UGDO, Trunk Storage Bin, Carbon Fiber Roundels, Black ///M Logo Oil Cap, Fr. Plate Delete, Black BMW Rr. Tag Holder, & Debadged

This thread has more than 20 replies. Click here to review the whole thread.

Posting Permissions

  • You may post new threads
  • You may post replies
  • You may not post attachments
  • You may not edit your posts
1e2 Forum