Reply to Thread

Post a reply to the thread: 1991 E34 Electrical Problem

Your Message

Click here to log in

Please correctly re-type the phrase f o o t d o c t o r in the form box. Re-type it without the extra spaces and put the one space where it should be. We apologize for having to do this but this silliness helps slow the spammers.


Additional Options


Topic Review (Newest First)

  • 05-01-2009, 04:13 PM


  • 05-01-2009, 04:12 PM

    Re: some links for you to survival in Germany

  • 05-01-2009, 08:06 AM

    some links for you to survival in Germany

    to get cheap parts.
    Andre Abenson is quite good with used parts, he lives in Wiesbaden near Frankfurt, also speaks a bit English.
    Well known among the E32 and E34 drivers, reliable, cheap.
    the phone and email number is in all the offers there, so just call him or send him an email. He has more than he can list.

    Quality parts only, no chep stuff, Cristpger there speaks English

    Well known shop on the E34 and E32 forum in Germany, most of them drive E34.

    Goede 2QQtZkm
    front and rear sus parts, shocks, brakes. If not lised in the auction house, call them. They can supply all for your car.

    from Berlin:
    In Germany to select parts, you always have to select the KBA numbers:
    KBA-Nr. (2/3)
    see the left side in your link above. Your 1991 525i E34 M50 192 HP 24V
    has the
    KBA-Nr: 0005-493
    note that number down, then inster there and all parts will pop up which fit your car.
    I have done that for you now, hopefully the direct link will work
    and here my translation help

    Abgasanlage = exhaust system
    Achsaufhängung/Radführung/Räder = sus/steering/wheels
    Antennen / Radiozubehör=antenna/radio accesories
    Antriebswelle / Antriebswellengelenk / Manschetten = drive shaft/drive shaft joints/rubber seals
    Bremsanlage = brakes
    Elektrik: Beleuchtung / Anlasser / Lichtmaschine =electrics/lights/starter/generator parts
    Filter /filters
    Getriebe =gear/transmission
    Heizung / Lüftung = heating and airation
    Karosserie / Stoßstange / Kotflügel / Spiegel = chassis parts/bumpers/fenders/mirrors
    Klimaanlage / climate control/aircon
    Komfortsysteme = comfort systems
    Kraftstofförderanlage / Tank / Tankverschluß= fuel supply/gas tank/fuel gas flap
    Kupplung: Kupplungssatz / Ausrücklager / Kupplungsseil = clucth parts/clutch bearings/clutch bowden cable
    Kühlung / Wasserpumpe / Thermostat=engine cooling/water pump/thermostat
    Lenkung / Servopumpe / Spurstange / Lenkgetriebe =steering/power steering pump/tie rods and stuff/steering gear
    Motor / Motoröl / Dichtungen / Ölwanne / Stößel = engine parts
    Scheibenwischer / Wischermotor / Wischerpumpe=wiper+washer system parts
    Stoßdämpfer / Federn / Federbeinlager / Domlager = suspension parts such as shocks, springs, shock mounts
    Zahnriemen / Keilriemen / Spannrollen / Umlenkrollen = belts/rollers/tensiones etc
    Zündungsteile = ignition system parts
    German Ebay, fixed to E34 parts:
    keep this link: ZsearchQQcopagenumZ1QQfcclZ1QQfclZ4QQfromZR10QQfso oZ1QQfsopZ1QQftrtZ1QQftrvZ1QQga10244Z10425QQsabfmt sZ1QQsacatZ131090QQsaobfmtsZclassifiedQQsaobfmtsZi nsifShogun E32 Tech Tips:
  • 04-29-2009, 04:49 PM

    I live in Darmstadt

    I am stationed in Germany with the US Army. I have been in Darmstadt for a while, but my German is not good enough yet :(
  • 04-29-2009, 08:54 AM

    you live in Germany?

    because you mention ADAC and km instead of miles.
    First of all for the feedback.
    There is a very good German forum for the E34 drivers. So if you understand, register there too
    I am also a member there, very good knowedge in electronics also there.
    Shogun E32 Tech Tips:
  • 04-26-2009, 11:11 AM

    Problem Solved!

    I found the problem. The brushes on the voltage regulator are worn. One of the brushes was not even making contact with the alternator ring. Off to the dealer tomorrow.

    Contrary to what I read, this was NOT an easy task. It might be easier to access some of the hardware from below the car, but I was working on the street and did not have access to a lift.

    After fumbling around for an hour trying to take the wiring harness off the alternator, I decided to remove the two mounting bolts and maneuver the alternator around to remove the harness nuts.
  • 04-25-2009, 04:41 PM

    Re: 1991 E34 Electrical Problem

    Now that I think about it, the first light that comes on is the yellow ABS light on the far right of the instrument cluster, not the SRS.
  • 04-25-2009, 04:26 PM

    1991 E34 Electrical Problem

    I have a problem with my 1991 525i E34 M50 that is puzzling, at least to me. I have searched the Internet and this forum for a similar situation, but could not find one.

    Last night as I was driving home from work, the SRS light on the dash came on. About a kilometer later, one of the other dash warning lights came on and then then I noticed that the headlights were getting dim.

    As I braked for a traffic light, the engine started running very rough and the whole car started shaking as the engine surged. When I turned off the lights and heater, the surging stopped, but started again when I turned the lights back on.

    When the traffic light turned green, it took me about 20 seconds to crawl through the intersection. Fortunately, there was no traffic and I limped to a place to stop. By the time I coasted to a spot, the engine had died and there was very little electrical power left to illuminate the interior lights.

    My first thought was the serpentine belt had broken and I had been running on battery power alone. When I opened the hood, everything appeared as it should. The belt was intact, there were no signs of any fluids leaking, and the alternator was cold to the touch.

    After about five minutes of scratching my head, prodding relays, and tugging on cables, I noticed that the interior lights were now bright. I turned the ignition key and the car started fine and ran as if nothing were wrong. Even turning on the headlights and heater did not cause any changes in RPM or cause any warning lamps to illuminate. Since I lived about one kilometer away, I drove home without a problem.

    Today, I decided to drive to the next town, which is about 15 kilometers away. As I neared an intersection, the SRS light came on and about 30 seconds later, all of the dash instruments died, followed quickly by the engine. When I turned the key to the run position, the lights and gauges on the dash were dead. When I tried to start the engine, there was nothing.

    After about ten minutes, it appeared as if all power was restored, except the car still would not start. When I turned the key to the run position, all of the normal dash lights came on and the gauges were active. When I tried to start the engine, the starter motor would engage, but after one attempt to turn, it would stop. It had the appearance of a dead battery.

    I called ADAC and waited for about 15 minutes, all the while making new friends at the busy intersection. On a whim, I tried to start the car and as it did last night, it started without a problem.

    About ten minutes later, when I was almost at my destination, the SRS light came on, but I had parked before the total power loss occurred. The car remains where I parked it and my wife picked me up.

    If I can rule out demonic possession, what could be causing this problem?

    If it helps, here are more particulars about the car.

    It has about 295,000 kilometers on the original engine
    Automatic transmission (replaced ten years ago)
    New thermostat (previous thermostat failed open)
    I keep getting the coolant level warning, even though the level is fine.

    I appreciate any help!

Posting Permissions

  • You may post new threads
  • You may post replies
  • You may not post attachments
  • You may not edit your posts
1e2 Forum